King County jail lost water 16 times since 2018

The building has been plagued with water failures stemming from Aquatherm pipes.

Inmates, staff and residents of the homeless shelter at the King County Correctional Facility have been without water 16 times within the past year and a half following significant failures in the piping system.

The county’s downtown Seattle jail, housing more than 1,000 inmates, has experienced ongoing system failures with its Aquatherm pipes, which were installed in 2012 and marketed as having a 60-year lifespan. However, by 2015, the jail’s water service was regularly interrupted by major leaks that left everyone in the building without water. When major leaks happened, the entire system would be shut down to make repairs, said King County’s director of facilities management Anthony Wright.

“It kept failing and probably for the first five or 10 [leaks], we were negotiating with the manufacturers and they were covering them under warranty,” Wright said at a July 23 county budget and fiscal management meeting.

In the face of ongoing leaks, the county filed a lawsuit against the German-based manufacturer Aquatherm this spring, at which point the company stopped providing repair services. Since then, the county has secured another contractor for repair work. King County Executive Dow Constantine is asking for $23.5 million to completely overhaul the jail’s piping system and for the county to declare an emergency. This ordinance will appear on the July 24 King County Council agenda.

Some leaks have caused damage to flooring and cabinets as well as drip damage and, in some cases, flowing water. One picture presented at the meeting showed 180-degree temperature water jettisoning from a pipe onto a mechanical panel.

“When it’s doing that, we have to shut the water down to the system,” Wright said. “The whole complex either lacks cold water or hot water or both, depending on which pipe has failed.”

These failures left inmates, visitors and everyone else in the building reliant on using bottled water for drinking, flushing toilets and other essential uses at times. While the water system was shut down when large leaks broke out, Wright said the leaks on their own could create pressure loss on the upper floors of the buildings. In previous coverage, King County Council member Kathy Lambert said most repair work was done at night.

Wright said the jail has around 4.5 miles of piping that will need to be replaced, likely with a stainless steel system. There is no timeline for when it could be completed. And while the county is asking for $23.5 million, Wright said the total project cost may come in under budget.

King County sued Aquatherm in March to recover damages associated with replacing the system and damage to the facilities. The lawsuit, which names Aquatherm and several of its U.S. subsidiaries, as well as local contractors, alleges the problems are not unique to the jail.

“(The) unfair and deceptive acts were part of a pattern or generalized course of conduct, have been repeated and have the capacity for future repetition, and have injured other property owners in exactly the same fashion as King County,” according to the lawsuit.

Aquatherm pipes are made from a material called polypropylene-random (PP-R), which Wright said usually works well in places that have hard water unlike Seattle.

The Seattle Times reported in 2018 that the Via6 apartment project installed Aquatherm pipes during construction that had been deemed complete in 2013. The apartment complex has two, 24-story towers and 654 units. By 2018, the building’s management displaced tenants for a month to replace the piping after major water leaks and flooding. The building’s owners sued Aquatherm last year and litigation is ongoing.

The Edith Green-Wendell Wyatt Federal Building in Portland also installed Aquatherm pipes in recent years following renovations that were completed around 2013. By summer 2018, the federally-owned building began experiencing leaks, said property manager Chad Hutson with the General Services Administration (GSA).

“GSA is currently investigating the root cause for leaks with the assistance of the third-party consultant with the goal of permanently correcting the issue,” Hutson said in an email.

If the emergency ordinance is declared by the King County Council, the county could begin the process of replacing the pipes at the correctional facility immediately.

More in News

Fire along Twisp River Road in the Okanogan Wenatchee National Forest in 2018. Courtesy photo
Wildfire response: State unveils funding legislation proposal

Last year, Department of Natural Resources responded to record number of wildfires.

A new report, complete with recommendations to the Legislature, has been released by a statewide task force that was formed to address a lack of child care in Washington. File photo
Report outlines lack of child care in Washington

In King County, supply doesn’t meet demand for child care.

Racing left Renton, still bothers residents

Police say efforts were successful, but racers just moved across the city border

Renton Rotary selects Youth of the Month for December

The award is given to students who have leadership abilities, maintain a good GPA and volunteer in the community.

Photo by Haley Ausbun. Booths for kids to make Christmas tree decorations were one of the highlights at the pop-up market during the downtown tree lighting in Renton. Saturday, Nov. 30 at the Renton Pavilion Events Center.
Lighting up the holiday season

Photos by Haley Ausbun. Renton Small Business Saturday and Downtown Tree Lighting,… Continue reading

Photo by Danny Rodgers for The Salvation Army.
                                Seattle Seahawks Defensive End L.J. Collier volunteers at The Salvation Army community meal on Wednesday, Nov. 26, helping serve a traditional Thanksgiving meal. The Salvation Army serves a free meal to the public, Monday through Thursday, 5:15 to 6:30 p.m. Also pictured are Captain Isaias Braga, director of The Salvation Army in Renton, and Larissa Braga, volunteer.
Seahawk feeds Rentonites in need

Photo by Danny Rodgers for The Salvation Army. Seattle Seahawks Defensive End… Continue reading

Photo by Haley Ausbun. Wyman and Vicky Dobson, as Wyman Dobson receives a certificate and medal for being a founder of the Nishiwaki-Renton sister cities. Wyman recently retired and sold his family building, where he had been an attorney for 59 years.
Dobson shuts his doors, leaves behind a nearly 60-year legacy

Long-time local lawyer, leader chooses to retire

Racing left Renton, still bothers residents

Police say efforts were successful, but racers just moved across the city border

Demonstrators from La Resistencia protest Amazon’s involvement with ICE. Photo courtesy of La Resistencia
How will the U.S. respond to climate refugees?

Business as usual has been harder borders, are there other ways to address climate migration?

Most Read